|
|
Hits: 4713
Size: 37 KB
Posted: 9/18/08
MultiFunction Switches used on '92-up Ford trucks, other Ford products, & other vehicles including t... | 
Hits: 3385
Size: 67.32 KB
Posted: 5/15/11
It's very common for older MFSs to slowly stop working, and replacements range from $40-200, so repa... | 
Hits: 2945
Size: 74.91 KB
Posted: 5/15/11
Hold the case together firmly as the screws are removed. The springs are near the hazard button, so... | 
Hits: 2526
Size: 76.38 KB
Posted: 5/15/11
The parts will be loose as soon as the case separates, so hold it this way. Sliding the top slightl... | 
Hits: 2374
Size: 70.57 KB
Posted: 5/15/11
While splitting the case, release the catch on the wiper connector using a fine flat screwdriver or ... |
Hits: 2482
Size: 73.75 KB
Posted: 5/15/11
At all times, make SURE the lever stays fully down on the rear case half, including when you set the... | 
Hits: 2299
Size: 86.06 KB
Posted: 5/15/11
There are several possible failures, and this may be a rare one: the main headlight wiper overheated... | 
Hits: 2388
Size: 90.28 KB
Posted: 5/15/11
This is probably the most common failure: simple corrosion of the contacts & wipers. All circuits w... | 
Hits: 2396
Size: 63.16 KB
Posted: 5/15/11
These are the functions of the wipers & sliders. If you can't read the text labels in the image, cl... | 
Hits: 2549
Size: 55.81 KB
Posted: 5/15/11
These are the functions of the contacts. If you can't read the text labels in the image, click it t... |
Hits: 7188
Size: 83.84 KB
Posted: 5/15/11
Rear case assembly | 
Hits: 2398
Size: 93.56 KB
Posted: 5/15/11
Rinse the contacts with electrical contact cleaner, then polish them with fine steel wool or emery p... | 
Hits: 2199
Size: 87.53 KB
Posted: 5/15/11
Cleaning the wipers is more difficult because they're spring-loaded, and some are on loose parts. K... | 
Hits: 2170
Size: 80.12 KB
Posted: 5/15/11
Once all the contacts are clean, apply a light film of silicone electrical grease (NOT dielectric, t... | 
Hits: 2405
Size: 84.54 KB
Posted: 5/15/11
To clean the wiper switch, it's not necessary to remove the MFS from the column. Just pop the cap o... |
Hits: 2173
Size: 99.67 KB
Posted: 5/15/11
To clean the wiper switch, it's not necessary to remove the MFS from the column. Just pop the cap o... | 
Hits: 2351
Size: 84.99 KB
Posted: 5/15/11
To clean the wiper switch, it's not necessary to remove the MFS from the column. Just pop the cap o... | 
Hits: 2315
Size: 73.91 KB
Posted: 5/15/11
As the collar comes off, watch for the detent pins & spring to fall out (the brass pin near the word... | 
Hits: 2527
Size: 61.13 KB
Posted: 5/15/11
Before removing the switch guts, note the position for reassembly. This shows the switch in the OFF... | 
Hits: 2330
Size: 80.38 KB
Posted: 5/15/11
After cleaning the contacts (with Electrical Contact Cleaner), apply a light film of silicone electr... |
MultiFunction Switch