| Date | Type | Mileage | Title / Description | $ Amount |
| 07/24/07 | Maintenance | 203000 | Fuel Pump
Installed Walbro 155LPH fuel pump from APEusa.com | 110.00 |
| 07/08/07 | Maintenance | 203000 | Fuel Filter
Replaced fuel filter | 15.00 |
| 05/09/07 | Miscellaneous | 201500 | Weather Stripping
Installed all-black lower weather strip from 94-95 SHO on all doors. | 0.00 |
| 05/07/07 | Repair | 201500 | Power Window Motor
Replaced the DS rear power window motor with one from a wreckers. | 0.00 |
| 05/07/07 | Repair | 201500 | Speaker
Replaced Pass. front speaker with stock JBL from wreckers. | 0.00 |
| 05/06/07 | Modification | 201400 | D4U1 ECU
replaced the stock 93 ECU with a D4U1 from a 94-95. | 45.00 |
| 03/25/07 | Maintenance | 200150 | Change Transmission Fluid
Used 9L of Valvoline ATF fluid. | 50.00 |
| 03/21/07 | Repair | 199950 | Alternator
After having continuous problems with the previous alternator (rebuilt several times), I have given up on it and purchased a new remanufactured one from Part Source. Champion part, 3yr warranty. Dead one failed just like before, voltage regulator didn't produce a charge when warm. | 280.00 |
| 03/04/07 | Repair | 199500 | Neutral Safety Switch
Original NSS/MLPS failed causing no ignition signal to reach the starter solenoid. Replaced with a new Ford unit, p/n F5DZ7F293BA. | 68.00 |
| 03/04/07 | Maintenance | 199500 | Starter
After replacing the MLPS, the car would turn over but the starter seemed weak. Upon disassembly, the entire unit was filled with oil. Instead of rebuilding, a new Champion reman'ed starter was installed. 3yr warranty. $55 core for the old one. | 216.00 |
| 12/08/06 | Repair | 198500 | Alternator
After 8 months, the alternator went out again. The thermal cut-off switch in the voltage regulator (used to protect the circuit from overheating) went bad and was turning off the alternator prematurely. Replaced the regulator and all is good. No cost, warranty work. | 0.00 |
| 11/28/06 | Repair | 198500 | Rear Struts/Springs
Replaced rear struts and springs with two new motorcraft units from A1 wreckers.
struts: $45x2 = $90
pinch bolts: $20 (pack of four from ford, only needed two)
control arm to spindle bolt/nut: $3x4=$12 | 122.00 |
| 10/10/06 | Maintenance | 197400 | Emissions Test
Failed the first test, NOx ppm too high.
Test One, NOx ppm 431 @ 40 km/h test.
Cleaned EGR tube and nostrils.
Test Two, limit / reading 40 km/h, limit / reading idle
HC ppm, 55 / 31, 200 / 27
CO%, 0.31 / 0.14, 1.0 / 0.06
NOx ppm, 0408 / 126
$35 + 17.50 (retest) | 52.50 |
| 10/02/06 | Modification | 197000 | Mufflers
Installed 2 new Stormer mufflers. | 235.00 |
| 07/05/06 | Maintenance | 194600 | Rear Brakes
Replaced:
- Left rear caliper
- L/R rear steel lines
- L/R Rubber Flex Lines
- L/R Pads (Wagner, Premium Organic)
- L/R Rotors (Economy)
- Bleed all 4 corners | 320.00 |
| 06/07/06 | Repair | 193500 | Accessory Belt Tensioner
Accessory belt tensioner died returning from trip to Hamilton, ON. Tow, $60. Ordered used tensioner from SHOForum member, $50.
Also Pressed new bearings (again...) into upper idler pulley, $30.
I did not include tow cost in total. | 80.00 |
| 04/17/06 | Maintenance | 192500 | Fuel Filter
replaced fuel filter | 15.00 |
| 04/17/06 | Maintenance | 192500 | Air Filter
replaced w/ new paper element filter. | 15.00 |
| 04/12/06 | Repair | 192100 | Starter repair
Replaced Starter solenoid, cleaned internals and replaced brushes. | 35.00 |
| 04/12/06 | Modification | 192100 | Battery Cables
Replaced factory battery cables with custom ones. All 1/0g cable. Positive: Starter to battery (top post), battery to alternator (side post). Negative: Starter to battery to body (T split at battery terminal) | 110.00 |
| 03/31/06 | Repair | 192000 | Alternator
Alternator AGAIN. Reman'd at Brantford Starter and Alternator. Voltage Regulator was bad. | 150.00 |
| 01/26/06 | Repair | 191200 | Alternator
Installed new rebuilt alternator bought from member of shopower.com | 150.00 |
| 01/01/06 | Maintenance | 190000 | Tie Rods
Replaced inner and outer tie rods with lifetime warranty TRW parts. Outers are greasable. | 85.00 |
| 01/01/06 | Modification | 190000 | Alternator Wire
Installed a 0g wire from alternator output to positive battery terminal. | 0.00 |
| 10/10/05 | Modification | 188400 | Stereo Receiver
Installed Pioneer DEH-2600 Head Unit. Used wiring kit to bypass factory amp setup. | 0.00 |
| 08/14/05 | Maintenance | 183800 | Transmission Fluid and Filter
8L dino (non-synthetic) fluid and NAPA filter/gasket set.
Fluid: $25
Filter Kit: $35 | 60.00 |
| 07/23/05 | Maintenance | 183200 | Connecting Rod Bearings
Replaced connecting rod bearings; Clevite | 100.00 |
| 07/19/05 | Modification | 183000 | Triple Gauges
Installed Oil Pressure, Transmission Temp, and voltmeter. | 23.00 |
| 07/09/05 | Maintenance | 182500 | Thermostat
Bought a new thermostat after the last one siezed and blew a hole in the upper rad hose. I bought a Motocraft one this time. | 43.00 |
| 07/09/05 | Maintenance | 182500 | Upper rad hose
Replaced upper rad hose | 20.00 |
| 06/23/05 | Repair | 182300 | Upper Idler Pulley Bearing
Had a new bearing pressed into the upper idler pulley. I think it got wrecked when I left it outside in the rain overnight last week when I replaced the alternator. Doh! | 20.00 |
| 06/15/05 | Maintenance | 182300 | Battery
Pow-R-Surge 7000 w/ 6yr warranty. 1020ca / 875cca | 114.00 |
| 06/14/05 | Maintenance | 182300 | Alternator
installed a new 120A rebuilt alternator | 184.00 |
| 06/14/05 | Maintenance | 182300 | Water Pump
Old water pump blew when the alternator died. Installed a new rebuilt water pump from NAPA. 134.00 ($184 - $50 core) | 134.00 |
| 05/14/05 | Maintenance | 181200 | Ground Cables
Used new 4g stereo wire to replace ground straps on rear of intake to strut tower, and another for battery to rad support connection. | 0.00 |
| 05/09/05 | Modification | 181000 | Blazer Driving Lamps
Installed Blazer Driving Lamps
$0 (gift) | 0.00 |
| 03/21/05 | Miscellaneous | | New Stereo Setup
1x Kenwood KAC-629s
1x Kenwood 10" KFC-W2500
2x Sony 6"x9" Xplod's (first series)
I installed the W2500 in the stock jbl sub box. The sub apparently requires .34 cubic feet (11 litres), and the box is .42 cubic feet (12 litres). The Kenwood amp powers the sub, while the Xplod's replace the factory 5x7's in the rear deck, using the existing stock JBL amp. | 0.00 |
| 01/30/05 | Maintenance | 179000 | Power Steering Flush
Flushed 6 litres of type-f ATF fluid through power steering fluid resevoir. | 6.00 |
| 01/30/05 | Maintenance | 179000 | Battery Cable Clamps
| 3.00 |
| 01/13/05 | Maintenance | 178700 | Coolant Flush
Flushed coolant using Prestone Super flush (or whatever its called), and replaced with distilled water/Prestone anti-freeze. ~50/50 mix | 17.00 |
| 12/14/04 | Maintenance | 177500 | Timing Belt Tensioner
The old one died, had to have a used one shipped from a SHOForum member in MI. after shipping/duty/brokerage and whatnot, it came to $100.
The old one came off a car w/ 70,000 or so miles. | 100.00 |
| 11/06/04 | Modification | 177000 | Brake Upgrade
Upgraded front brakes to 96-99 SHO brakes.
Parts:
2x Re-manufactured Wagner calipers (L/R)
2x used 1995 Lincoln Continental caliper brackets (p/n #FN74)
2x used 1994 Mercury Sable spindles (w/ abs)
2x Wagner premium rotors
Wagner Thermoquiet Ceramic pads (p/n #598 )
Misc. dust boots, bolts, fluids, paint, etc...
Total=$560 - $85 (core for old calipers) = $475 | 475.00 |
| 10/16/04 | Miscellaneous | | Lebra Hood Cover
Found mint condition hood bra @ cathcart. price was in with caliper brackets for brake upgrade. | 0.00 |
| 10/01/04 | Maintenance | 176000 | Emission Test
limit / reading 40 km/h, limit / reading idle
HC ppm, 64 / 47, 200 / 23
CO%, 0.35 / 0.14, 1.0 / 0.03
NO ppm, 0470 / 321 | 35.00 |
| 09/01/04 | Maintenance | 174000 | Spark Plug Wires
Motocraft, p/n WRE-4081 | 214.00 |
| 08/23/04 | Maintenance | 173000 | Vehicle Speed Sensor
Replaced with Motocraft part. Part: $70, Labour: $200 | 270.00 |
| 08/23/04 | Maintenance | 173000 | Air Filter
Replaced w/ stock paper Fram air filter | 15.00 |
| 07/10/04 | Maintenance | 170000 | ECT Sensor
Motocraft, p/n DY-681 | 95.00 |
| 06/01/04 | Maintenance | 168000 | Accessory Belt
Motocraft, p/n 1F1Z-8620-AA
Ordered from Shonut | 30.00 |
| 06/01/04 | Maintenance | 168000 | Battery (re-conditioned)
| 30.00 |
| 06/01/04 | Maintenance | 168000 | Camshaft/Crankshaft seals
Crankshaft Seal: Motocraft, p/n E9DZ-6700-B.
Camshaft seals were part of the gasket set from Shonut. | 11.00 |
| 06/01/04 | Maintenance | 168000 | New gaskets
Upper gasket set from Shonut, including intake and butterfly gaskets and others. | 208.00 |
| 06/01/04 | Maintenance | 168000 | Spark plugs
Motocraft, AGSP-32PPF6 | 69.00 |
| 06/01/04 | Maintenance | 168000 | Valve lash adjustment
Kit rental from Shonut, including 56 new/used shims. Price includes deposit. | 372.00 |
| 06/01/04 | Maintenance | 168000 | Timing belt
Gates, p/n 95248
Ordered from Global4autoparts.com | 62.50 |
| 06/01/04 | Modification | 168000 | TB coolant bypass
| 0.00 |
| 03/20/04 | Repair | 164000 | Temperature Sensor
Napa, replaced under warranty for last ECT | 0.00 |
| 01/18/04 | Maintenance | 163000 | Temperature Sender
Napa, p/n# TS6628 | 10.00 |
| 01/18/04 | Maintenance | 163000 | Thermostat
| 8.00 |
| 01/18/04 | Maintenance | 163000 | Fuel Filter
| 12.00 |
| 01/18/04 | Maintenance | 163000 | Temperature Sensor
Napa, p/n# TS4005 | 48.00 |
| 12/01/03 | Miscellaneous | | GTS Headlight Covers
| 60.00 |
| 12/01/03 | Miscellaneous | | Sylvania Silverstar's
| 60.00 |
| 10/01/03 | Miscellaneous | | Reverse-glow gauges
Ebay gauges originally cost $35, but after shipping/duty/etc, they came to $80. | 80.00 |
| 07/23/03 | Maintenance | 161000 | Brakes
| 450.00 |
| 07/22/03 | Maintenance | 159000 | Idler Pulleys
Upper and lower, new Motocraft pulleys. | 355.00 |
| 06/01/03 | Miscellaneous | | Painted body lettering
filled in body lettering and lettering on wheel centercaps with black paint. | 0.00 |
| 05/15/03 | Maintenance | 157000 | Water Pump
Water pump was replaced as term of sale. I didn't pay, it was done by the dealer's shop. | 0.00 |
| 05/15/03 | Modification | | Toyo Proxes H4
Tires were installed on the car by previous owner. | 0.00 |
| 05/15/03 | Modification | | SLO Hood
Car had a Non-SHO hood with 2 lines running down the length of the hood, instead of sable hood. | 0.00 |
| 05/01/03 | Modification | | Removed silencer cone
removed silencer cone from intake and gutted fender airbox. | 0.00 |
| Total | 5,947.00 |
