This is all the lumber for the raised stage in this church, and to support the baptistry. It's probably over three tons of wet treated pine.
I need a place for this text, and this is as good a spot as any:
==========================================
1996 Severe-Duty Maintenance Schedule
Severe Driving Conditions include one or more of the following:
1) Short trips of less than 10 miles (16km) when outside temperatures remain below freezing;
2) Towing a trailer; using a camper, roof-top carrier, or carrying maximum loads;
3) Operating in severe dust conditions
4) Operating during hot weather in stop-and-go "rush hour" traffic;
5) Extensive idling, such as police, taxi, or door-to-door delivery use;
6) Snow plowing
7) High speed operation with a fully-loaded vehicle (max. GVW);
Change engine oil & filter every 3 months or 3,000 miles (4800km) whichever occurs first.
(Click this for the
Normal Maintenance Schedule.)
Smallblock Oil Filter
Motorcraft FL-1A (w/factory oil cooler
Motorcraft FL820S)
Note: For items marked with a number in parentheses, see footnotes at the end of this schedule.
Note: Kilometer intervals are rounded off.
Note: The Severe-Duty Schedule provides maintenance intervals for replacing the
air cleaner filter if vehicle is driven in severe dust conditions. However, some driving conditions may require even more frequent air cleaner replacement intervals than those shown.
Note: For more info, click the linked text.
3,000 Miles (5,000 km)
* Change
engine oil and replace
oil filter.
* Check and lubricate clutch release lever (7.5L and 7.3L DI turbo diesel).
6,000 Miles (10,000 km)
* Change
engine oil and replace
oil filter.
*
Rotate tires and adjust
air pressure. (1) (2) (3)
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
9,000 Miles (15,000 km)
* Change
engine oil and replace
oil filter.
12,000 Miles (20,000 km)
* Change
engine oil and replace
oil filter.
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
15,000 Miles (25,000 km)
* Change
engine oil and replace
oil filter.
* Inspect engine
cooling system, hoses, and clamps and check coolant strength every 15,000 miles (25,000 km) or 12 months.
* For 7.3L DI turbo diesel engines, add 8-10 ounces of FW-15 to the engine coolant every 15,000 miles (24,000 km).
*
Rotate tires and adjust
air pressure. (1) (2) (3)
* Lubricate
transfer case shift lever pivot bolt and control rod connecting pins (4x4).
* Inspect disc
brake systems, hoses and lines. (5)
* Lubricate caliper slide rails (F-Super Duty). (5)
* Inspect
drum brake systems, hoses and lines.
* Change
fuel filter (recommended but not required for California certified vehicles).
* Change fuel filter every 15,000 miles (25,000 km) (7.5L DI turbo diesel only).
* Check
spring U-bolt torque (F-Super Duty).
* Inspect parking brake fluid (F-Super Duty).
18,000 Miles (30,000 km)
* Change
engine oil and replace
oil filter.
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
* Check and lubricate clutch release lever (7.5L and 7.3L DI turbo diesel).
21,000 Miles (35,000 km)
* Change
engine oil and replace
oil filter.
* Change
automatic transmission fluid.
24,000 miles (40,000 km)
* Change
engine oil and replace
oil filter.
*
Rotate tires and adjust
air pressure. (1) (2) (3)
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
* Lubricate throttle kickdown or
TV lever ball studs.
27,000 Miles (45,000 km)
* Change
engine oil and replace
oil filter.
30,000 Miles (50,000 km)
* Change
engine oil and replace
oil filter.
* Replace
air cleaner filter every 30,000 miles (50,000 km) or 30 months. (6)
* Replace the air cleaner filter when the restriction gauge is in the red zone (7.3L DI turbo diesel only). (6)
* Inspect engine
cooling system, hoses, and clamps and check coolant strength every 15,000 miles (25,000 km) or 12 months.
* For 7.3L DI turbo diesel engines, add 8-10 ounces of FW-15 to the engine coolant every 15,000 miles (25,000 km).
* Replace
crankcase emission air filter. (4.9L, 5.0L manual transmission and 7.5L only.) (6)
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
* Lubricate
transfer case shift lever pivot bolt and control rod connecting pins (4x4).
* Inspect disc
brake systems, hoses and lines. (5)
* Lubricate caliper slide rails (F-Super Duty). (5)
* Inspect
drum brake systems, hoses and lines.
* Change
fuel filter (recommended but not required for California certified vehicles).
* Change fuel filter every 15,000 miles (25,000 km) (7.3L DI turbo diesel only).
* Inspect and lubricate
front wheel bearings. (5)
* Inspect
parking brake system for damage and
operation.
* Change
manual transmission oil.
* Lubricate
front axle RH axle shaft slip-yoke (4x4).
* Inspect and lubricate
spindle needle bearings (4x4).
* Change
rear axle lube (F-Super Duty only). (7)
* Inspect and lubricate
hub locks (4x4).
* Inspect parking brake fluid (F-Super Duty).
* Check
spring U-bolt torque (F-Super Duty).
33,000 Miles (55,000 km)
* Change
engine oil and replace
oil filter.
*
Rotate tires and adjust
air pressure. (1) (2) (3)
* Check and lubricate clutch release lever (7.5L and 7.3L DI turbo diesel).
36,000 Miles (60,000 km)
* Change
engine oil and replace
oil filter.
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
39,000 Miles (65,000 km)
* Change
engine oil and replace
oil filter.
42,000 Miles (70,000 km)
* Change
engine oil and replace
oil filter.
* Change
automatic transmission fluid.
*
Rotate tires and adjust
air pressure. (1) (2) (3)
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
45,000 Miles (75,000 km)
* Change
engine oil and replace
oil filter.
* Inspect engine
cooling system, hoses, and clamps and check coolant strength every 15,000 miles (25,000 km) or 12 months.
* For 7.3L DI turbo diesel engines, add 8-10 ounces of FW-15 to the engine coolant every 15,000 miles (25,000 km).
* Lubricate
transfer case shift lever pivot bolt and control rod connecting pins (4x4).
* Inspect disc
brake systems, hoses and lines. (5)
* Lubricate caliper slide rails (F-Super Duty). (5)
* Inspect
drum brake systems, hoses and lines.
* Change
fuel filter (recommended but not required for California certified vehicles).
* Change fuel filter every 15,000 miles (25,000 km) (7.3L DI turbo diesel only).
* Inspect parking brake fluid (F-Super Duty).
* Check
spring U-bolt torque (F-Super Duty).
48,000 Miles (80,000 km)
* Change
engine oil and replace
oil filter.
* Change
engine coolant initially at 48,000 miles (80,000 km) or 48 months. Thereafter, Change
engine coolant every 30,000 miles (50,000 km) or 36 months (gasoline engines only).
* For 7.3L DI turbo diesel engines, add four (4) pints of FW-15 each time engine coolant is changed.
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
* Lubricate throttle kickdown or
TV lever ball studs.
* Check and lubricate clutch release lever (7.5L and 7.3L DI turbo diesel).
51,000 Miles (85,000 km)
* Change
engine oil and replace
oil filter.
*
Rotate tires and adjust
air pressure. (1) (2) (3)
54,000 Miles (90,000 km)
* Change
engine oil and replace
oil filter.
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding.
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
57,000 Miles (95,000 km)
* Change
engine oil and replace
oil filter.
60,000 Miles (100,000 km)
* Change
engine oil and replace
oil filter.
* Inspect engine
cooling system, hoses, and clamps and check coolant strength every 15,000 miles (25,000 km) or 12 months.
* Replace
air cleaner filter every 30,000 miles (50,000 km) or 30 months. (6)
* Replace the air cleaner filter when the restriction gauge is in the red zone (7.3L DI turbo diesel only). (6)
* Replace
crankcase emission air filter.
* Replace
PCV valve. (8 )
* Check
thermactor hoses and clamps (recommended but not required).
* Inspect
accessory drive belts.
* Replace
spark plugs (gasoline engines only).
*
Rotate tires and adjust
air pressure. (1) (2) (3)
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
* Lubricate
transfer case shift lever pivot bolt and control rod connecting pins (4x4).
* Inspect disc
brake systems, hoses and lines. (5)
* Lubricate caliper slide rails (F-Super Duty). (5)
* Inspect
drum brake systems, hoses and lines.
* Change
fuel filter (recommended but not required for California certified vehicles).
* Change fuel filter every 15,000 miles (25,000 km) (7.3L DI turbo diesel only).
* Inspect and lubricate
front wheel bearings (5).
* Inspect
parking brake system for damage and
operation.
* Lubricate
front axle RH axle shaft slip-yoke (4x4).
* Inspect and lubricate
spindle needle bearings (4x4).
* Inspect and lubricate
hub locks (4x4).
* Change
transfer case oil (4x4).
* Change
manual transmission oil.
* Change
rear axle lube (F-Super Duty only). (7)
* Inspect parking brake fluid (F-Super Duty).
* Check
spring U-bolt torque (F-Super Duty).
63,000 Miles (105,000 km)
* Change
engine oil and replace
oil filter.
* For 7.3L DI turbo diesel engines, add 8-10 ounces of FW-15 to the engine coolant every 15,000 miles (25,000 km).
* Check and lubricate clutch release lever (7.5L and 7.3L DI turbo diesel).
* Change
automatic transmission fluid.
66,000 Miles (110,000 km)
* Change
engine oil and replace
oil filter.
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
69,000 Miles (115,000 km)
* Change
engine oil and replace
oil filter.
*
Rotate tires and adjust
air pressure. (1) (2) (3)
72,000 Miles (120,000 km)
* Change
engine oil and replace
oil filter.
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
* Lubricate throttle kickdown or
TV lever ball studs.
75,000 Miles (125,000 km)
* Change
engine oil and replace
oil filter.
* Inspect engine
cooling system, hoses and clamps and check coolant strength every 15,000 miles (25,000 km) or 12 months.
* Lubricate
transfer case shift lever pivot bolt and control rod connecting pins (4x4).
* Inspect disc
brake systems, hoses and lines. (5)
* Lubricate caliper slide rails (F-Super Duty). (5)
* Inspect drum brake linings, hoses and lines.
* Change
fuel filter (recommended but not required for California certified vehicles).
* Change fuel filter every 15,000 miles (25,000 km) (7.3L DI turbo diesel only).
* Inspect parking brake fluid (F-Super Duty).
* Check
spring U-bolt torque (F-Super Duty).
78,000 Miles (130,000 km)
* Change
engine oil and replace
oil filter.
* Change
engine coolant every 30,000 miles (50,000 km) or 36 months (gasoline engines only).
* For 7.3L DI turbo diesel engines, add four (4) pints of FW-15 each time engine coolant is changed.
*
Rotate tires and adjust
air pressure. (1) (2) (3)
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
* Check and lubricate clutch release lever (7.5L and 7.3L DI turbo diesel).
81,000 Miles (135,000 km)
* Change
engine oil and replace
oil filter.
84,000 Miles (140,000 km)
* Change
engine oil and replace
oil filter.
* Check
clutch reservoir fluid level.
* Change
automatic transmission fluid.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
87,000 Miles (145,000 km)
* Change
engine oil and replace
oil filter.
*
Rotate tires and adjust
air pressure. (1) (2) (3)
90,000 Miles (150,000 km)
* Change
engine oil and replace
oil filter.
* Replace
air cleaner filter every 30,000 miles (50,000 km) or 30 months. (6)
* Replace the air cleaner filter when the restriction gauge is in the red zone (7.3L DI turbo diesel only). (6)
* Inspect engine
cooling system, hoses and clamps and check coolant strength every 15,000 miles (25,000 km) or 12 months.
* Inspect
accessory drive belts.
* Replace
crankcase emission air filter (4.9L, 5.0L manual transmission and 7.5L only). (6)
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
* Inspect disc
brake systems, hoses and lines. (5)
* Lubricate caliper slide rails (F-Super Duty). (5)
* Inspect
drum brake systems, hoses and lines.
* Change
fuel filter (recommended but not required for California certified vehicles).
* Change fuel filter every 15,000 miles (25,000 km) (7.3L DI turbo diesel only).
* Inspect and lubricate
front wheel bearings. (5)
* Inspect
parking brake system for damage and
operation.
* Change
manual transmission oil.
* Lubricate
transfer case shift lever pivot bolt and control rod connecting pins (4x4).
* Lubricate
front axle RH axle shaft slip-yoke (4x4).
* Inspect and lubricate
spindle needle bearings (4x4).
* Change
rear axle lube (F-Super Duty only). (4)
* Inspect and lubricate
hub locks (4x4).
* Inspect parking brake fluid (F-Super Duty).
* Check
spring U-bolt torque (F-Super Duty).
93,000 Miles (155,000 km)
* Change
engine oil and replace
oil filter.
* For 7.3L DI turbo diesel engines, add 8-10 ounces of FW-15 to the engine coolant every 15,000 miles (25,000 km).
* Check and lubricate clutch release lever (7.5L and 7.3L DI turbo diesel).
96,000 Miles (160,000 km)
* Change
engine oil and replace
oil filter.
*
Rotate tires and adjust
air pressure. (1) (2) (3)
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
* Lubricate throttle kick-down or
TV lever ball studs.
99,000 Miles (165,000 km)
* Change
engine oil and replace
oil filter.
* Replace
rear axle lube.
102,000 Miles (170,000 km)
* Change
engine oil and replace
oil filter.
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
105,000 Miles (175,000 km)
* Change
engine oil and replace
oil filter.
* Inspect engine
cooling system, hoses, and clamps and check coolant strength every 15,000 miles (25,000 km) or 12 months.
*
Rotate tires and adjust
air pressure. (1) (2) (3)
* Change
automatic transmission fluid.
* Lubricate
transfer case shift lever pivot bolt and control rod connecting pins (4x4).
* Inspect disc
brake systems, hoses and lines. (5)
* Lubricate caliper slide rails (F-Super Duty). (5)
* Inspect
drum brake systems, hoses and lines.
* Change
fuel filter (recommended but not required for California certified vehicles).
* Change fuel filter every 15,000 miles (25,000 km) (7.3L DI turbo diesel only).
* Inspect parking brake fluid (F-Super Duty).
* Check
spring U-bolt torque (F-Super Duty).
108,000 Miles (180,000 km)
* Change
engine oil and replace
oil filter.
* Change
engine coolant every 30,000 miles (50,000 km) or 36 months (gasoline engines only).
* For 7.3L DI turbo diesel engines, add four (4) pints of FW-15 each time engine coolant is changed.
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
* Check and lubricate clutch release lever (7.5L and 7.3L DI turbo diesel).
111,000 Miles (185,000 km)
* Change
engine oil and replace
oil filter.
114,000 Miles (190,000 km)
* Change
engine oil and replace
oil filter.
*
Rotate tires and adjust
air pressure. (1) (2) (3)
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
117,000 Miles (195,000 km)
* Change
engine oil and replace
oil filter.
120,000 Miles (200,000 km)
* Change
engine oil and replace
oil filter.
* Inspect engine
cooling system, hoses, and clamps and check coolant strength every 15,000 miles (25,000 km) or 12 months.
* Replace
air cleaner filter every 30,000 miles (50,000 km) or 30 months. (6)
* Replace the air cleaner filter when the restriction gauge is in the red zone (7.3L DI turbo diesel only). (6)
* Replace
spark plugs (gasoline engines only).
* Replace
crankcase emission air filter (4.9L, 5.0L manual transmission and 7.5L only). (6)
* Replace
PCV valve. (8 )
* Check
thermactor hoses and clamps (recommended but not required).
* Inspect
accessory drive belts.
* Check
clutch reservoir fluid level.
* Inspect and lubricate automatic transmission
shift linkage.
* Inspect
exhaust system for leaks, damage or loose parts. Remove any foreign material trapped by exhaust shielding. (4)
* Lubricate
steering linkage suspension, driveshaft
U-joint and slip-yoke (if equipped with grease fittings). (5)
* Lubricate throttle kickdown or
TV lever ball studs.
* Lubricate
transfer case shift lever pivot bolt and control rod connecting pins (4x4).
* Inspect disc
brake systems, hoses and lines. (5)
* Lubricate caliper slide rails (F-Super Duty). (5)
* Inspect
drum brake systems, hoses and lines.
* Change
fuel filter (recommended but not required for California certified vehicles).
* Change fuel filter every 15,000 miles (25,000 km) (7.3L DI turbo diesel only).
* Inspect and lubricate
front wheel bearings. (5)
* Inspect
parking brake system for damage and
operation.
* Lubricate
front axle RH axle shaft slip-yoke (4x4).
* Inspect and lubricate
spindle needle bearings (4x4).
* Inspect and lubricate
hub locks (4x4).
* Change
transfer case oil (4x4).
* Change
rear axle lube (F-Super Duty only). (7)
* Change
manual transmission oil.
* Inspect parking brake fluid (F-Super Duty).
* Check
spring U-bolt torque (F-Super Duty).
(1) City delivery vehicles and other severe applications that require constant turning may need more frequent tire rotation.
Tire rotation interval may be based on the
tire wear.
(2)
Wheel lug nuts must be retightened to
proper torque specifications at 500 miles (800 km) of new vehicle operation 100 miles (160 km) and 500 miles (800 km) for vehicles equipped with dual rear wheels or equipped for snowplowing). Also retighten to proper torque specification at 500 miles (800 km) after (a) any wheel change or (b) any other time the
Wheel lug nuts have been loosened.
(3) On dual rear wheel vehicles, rotate the front tires side-to-side without disturbing the rear tires.
(4) It is normal for a certain amount of moisture and staining to be present around the muffler seams. The presence of soot, light surface rust or moisture does not indicate a faulty muffler.
(5) If the vehicle is operated "off road" in water that is deeper than the hubs (1/2 wheel height), then these items must be serviced daily.
(6) Extremely dusty conditions will require more frequent replacement of your
air filter. Check your air filter at 3,000 miles (5,000 km). If it is dirty, replace it and then keep replacing it at the same interval every 3,000 miles (5,000 km). If it is not dirty, check it again at 6,000 miles (10,000 km) and again at 9,000 miles (14,500 km) until the required maintenance interval is established. Do not go beyond 30,000 miles (48,000 km).
(7) F-SUPER DUTY APPLICATIONS must change axle lube every 30,000 miles (48,000 km) unless synthetic oil is used. Super Duty vehicles are NOT equipped with synthetic oil from the factory. Synthetic oil MUST BE changed at 100,000 mile (160,000 km) intervals.
(8 ) At 60,000 miles (96,000 km) dealer will replace the
PCV valve at no cost except on Canada and California vehicles.
For F-Super Duty Rear Axles Only:
The lube change interval should be shortened to 3,000 miles (4,800 km) or 3 months, whichever occurs first, under the following conditions:
* Extended trailer tow operation above 21°C (70°F) ambient.
* Wide open throttle for extended periods above 72 km/h (45 mph).
The 3,000-mile (4,800-km) change interval may be waived if the axle has been filled with Ford approved 75W-140 synthetic gear lubricant meeting WSL-M2C192-A, Ford specification F1TZ-19580-B.
==========================================
Owner Maintenance Checks
Vehicle maintenance checks and inspections should be performed by the owner or qualified service technician at the indicated intervals. The Owner Guide contains supporting specifications and service information.
Any adverse conditions should be brought to the attention of the dealer or qualified service technician as soon as possible.
The owner maintenance checks are generally not covered by warranties.
When Stopping for Fuel
* Check the
engine oil level.
* Check the
windshield washer fluid level.
* Look for
underinflated tires.
While Operating the Vehicle
* Note any changes in the sound of the exhaust or any smell of exhaust fumes in the vehicle.
* Check for
vibration in the steering wheel. Notice any increased steering effort or looseness in the steering wheel, or change in its straight-ahead position.
* Notice if the vehicle constantly turns slightly or "pulls" to one side when traveling on smooth, level road.
* When braking, listen and check for strange sounds, pulling to one side, increased brake pedal travel or effort.
* If any slipping or changes in the operation of the transmission occur, check the
transmission fluid level.
* Check automatic transmission PARK function.
* Check
parking brake.
* Verify proper
BRAKE bulb and
REAR ANTI-LOCK bulb check response when starting vehicle.
At Least Monthly
* Check
coolant level in the coolant recovery reservoir.
* Check operation of
lights, horn,
turn signals, windshield wipers and washers, and hazard warning flasher.
* Check for fluid leaks by inspecting the surface beneath the vehicle for oil, coolant, or other fluid drips. Clean water draining from the air conditioning system is normal.
At Least Twice a Year
* Check
power steering reservoir fluid level.
* Check fluid level in
clutch master cylinder.
* Check radiator, heater and air-conditioning hoses for leaks or damage.
* Check for
worn tires.
* Clean body and door drain holes.
* Flush complete underside of vehicle.
* Inspect underbody components for damage.
* Check
parking brake system.
* Check
headlamp alignment.
* Check
seat and shoulder belt webbing,
buckles and release mechanisms.
* Inspect
seat back latches for proper operation.
* Check air pressure in
spare tire.
At Least Once a Year
* Lubricate
door hinges, checks, and hood hinges.
* Lubricate door, hood, and deck/liftgate/
tailgate locks and latches.
* Lubricate
door rubber weatherstrips.
* Clean
battery and terminals and check electrolyte level on low maintenance (auxiliary and replacement) batteries.
